The total cost typically ranges from about $150 to $600, depending on parts and labor. In some cases it can be higher if extra components are involved or you opt for OEM (dealer) parts.
To understand the question in more detail, several elements influence the price: whether your Versa uses a single electric radiator fan or a dual-fan setup, the type of parts (OEM vs aftermarket), local labor rates, the vehicle’s model year and engine configuration, and whether additional cooling-system service is required.
What affects the cost
Key factors that drive the price of a radiator fan replacement on a Nissan Versa are:
- Parts cost: OEM (dealer) radiator fan assemblies are typically more expensive than aftermarket units. A single electric radiator fan can range roughly from $60 to $180 aftermarket, and $150 to $350 or more for OEM; dual-fan assemblies or fans with integrated shrouds tend to be higher.
- Labor costs and time: Labor rates vary by location. A typical replacement takes about 1 to 2 hours in most shops, with labor charges commonly around $80 to $150 per hour, plus any shop fees.
- Fan configuration: Some Versa models use one primary radiator fan, while others balance cooling with a second condenser fan; more fans or more complex wiring increases labor time and parts cost.
- Vehicle specifics: The Versa’s model year and engine type can affect access and the exact part number, which influences price.
- Additional cooling-system work: If the fan failure stems from or causes other issues (bad thermostat, cooling hoses, radiator damage, or leaky water pump), you may incur extra parts and labor costs.
- Location and shop type: Dealerships tend to be more expensive than independent repair shops or chain auto parts retailers that offer installation services.
Prices can vary widely by region and shop. Always obtain a written estimate that separates parts and labor before agreeing to service.
Typical cost ranges for a Nissan Versa
Below are rough ranges you might expect for a typical Versa replacement, based on common market pricing in the United States. Actual prices can vary by year, region, and the exact part used.
- Parts: Expect roughly $60 to $180 for an aftermarket single-radiator fan; $150 to $350 or more for an OEM or dual-fan assembly.
- Labor: Expect about 1 to 2 hours of labor at typical shop rates, roughly $80 to $150 per hour, or $80 to $300 total depending on locale and complexity.
- Total: In most cases, a full replacement runs about $140 to $600, though high-end OEM parts or dual-fan setups can push toward $600–$700 in some markets.
As a rule of thumb, plan for roughly $200 to $450 in the United States for a straightforward single-fan replacement with aftermarket parts and standard labor rates. If OEM parts or additional cooling-system work are involved, the cost can climb.
What the replacement typically involves
If you or a mechanic perform the replacement, this is the general sequence. Note that exact steps can vary by Versa year and whether one or two fans are involved.
- Disconnect the vehicle’s battery and ensure the engine is cool before starting.
- Remove any necessary components that block access to the fan(s), such as the engine shroud, radiator cover, or air intake ducting.
- Disconnect the electrical connector(s) and, if present, a fuse or relay for the fan circuit.
- Unbolt and remove the old radiator fan assembly; inspect the shroud and radiator for damage.
- Install the new fan assembly, reconnect electrical wiring, and reassemble any removed parts.
- Refill or top off cooling system if needed and perform a systems check to verify fan operation and proper cooling function; run the engine to operating temperature and test with AC engaged.
- Road-test the vehicle and verify there are no leaks or overheating warnings.
Prices can differ if both fans are replaced or if there are additional repairs required to the cooling system.
DIY considerations
Replacing a radiator fan is doable for a mechanically minded DIYer with access to the right tools, but it involves electrical work and coolant handling. If you’re unsure, it’s safer and often more cost-effective to have a professional handle the job.
When to call a professional
If you’re not comfortable with automotive electrical systems, or if the cooling system has other issues (leaks, thermostat problems, or a damaged radiator), seek a qualified technician.
Summary
In short, a Nissan Versa radiator fan replacement typically costs between about $150 and $600 in the United States, depending on parts and labor. Expect higher prices if you require OEM parts, a dual-fan setup, or if other cooling-system components need attention. Always get multiple estimates, confirm whether the quote includes parts and labor, and ensure the shop tests the cooling system after installation to prevent future overheating.