Expect roughly 1,000–2,000 dollars for a single catalytic converter replacement, and about 2,000–4,000 dollars if both converters are replaced, depending on OEM versus aftermarket parts and local labor rates.
The price you see on a quote depends on whether the Pilot needs one or two converters, the type of parts chosen (OEM vs aftermarket), sensor and hardware requirements, and where you have the work done. The 2016 Honda Pilot typically uses two catalytic converters, and costs can vary widely by region and shop.
What affects the price
Several factors drive the final bill, including the number of converters, part choice, labor rate, and any sensor work or additional exhaust components that must be replaced.
- Parts choice: OEM (direct-fit) catalytic converters generally cost more than aftermarket equivalents.
- Number of converters: replacing one converter is cheaper than replacing both (front and rear) on a single vehicle.
- Labor: installation time plus shop hourly rates vary by region and shop type (dealer vs independent shop).
- Additional parts and services: gaskets, clamps, O2 sensors, and diagnostic work can add to the cost.
- Vehicle condition and accessibility: severe corrosion or difficult access can raise labor hours.
- Regional regulations and disposal fees: some areas impose environmental or disposal charges.
Bottom line: the quote you receive will reflect the combination of these variables, so comparing multiple written estimates is wise.
Cost breakdown by scenario
Below are typical installed-cost ranges for a 2016 Honda Pilot, with distinctions between OEM and aftermarket parts and between replacing one or both converters.
- Single catalytic converter replacement (one unit): OEM installed roughly $1,050–$1,950; aftermarket installed roughly $450–$1,250.
- Two catalytic converters replacement (both front and rear): OEM installed roughly $2,100–$4,000; aftermarket installed roughly $800–$2,000.
These ranges include parts and labor but can vary based on the exact part numbers, sensor requirements, and local labor rates. It’s common for quotes to float within these bands, with higher-end estimates reflecting theft-related replacements or complex installations.
Tips to get a fair quote
To ensure you’re getting accurate pricing and not paying for unnecessary work, consider these steps before authorizing the repair.
- Obtain multiple written estimates from reputable shops, including dealer and independent exhaust specialists.
- Ask what the price includes: sensors, gaskets, clamps, disposal fees, and warranty length.
- Clarify whether the quote is for OEM or aftermarket parts and whether labor includes diagnostic scans or code clearing.
- Inquire about potential savings with aftermarket parts if you are comfortable with them, and verify emissions compliance in your state.
- Check for any current promotions or coupons and consider asking about a breakdown of labor hours used in the estimate.
Finally, if the converters were stolen, ensure the shop documents the theft and confirms the replacement is compliant with local emissions regulations to avoid future inspection issues.
Summary
For a 2016 Honda Pilot, replace one catalytic converter generally costs about 1,000–2,000 dollars installed (OEM vs aftermarket pricing included); replacing both typically runs roughly 2,000–4,000 dollars installed. Costs vary by part choice, labor rates, and region, so shoppers should gather several quotes and read the inclusions carefully to avoid surprises. A careful comparison, awareness of whether sensors or extra hardware are needed, and understanding local emissions requirements will help you secure a fair price.